|
|
|
2007 Kia Optima stalls ONLY after fillup
|
|
|
| |
|
|
kuririn
Novice
Jun 2, 2019, 1:11 PM
Post #1 of 12
(3122 views)
|
2007 Kia Optima stalls ONLY after fillup
|
|
|
Car: 2007 Kia Optima V-6 with 106,000 miles.
Problem: After filling up and stopping on the first click, when driving away from the gas station car stalls out. Stalls a few more times after restarting engine. After about 3 or 4 minutes of driving it disappears. ONLY stalls after filling up. No check engine light. Happened the past three fillups. Purge canister problem? Appreciate any help you can give. Cheers.
|
|
| |
|
|
Tom Greenleaf
Ultimate Carjunky
/ Moderator
Jun 2, 2019, 1:54 PM
Post #2 of 12
(3111 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
Is it setting a check engine light? Check the canister if soaked. It could be tricky if only does this a couple times and fine to pin this. It's true, don't ask for more than pump's click should click off faster if you go full speed if not doing that now.
Seems silly but fuel in ground tanks for some time is still quite cold and some days warm to hot it does expand some just not that fast to notice.
Try for laughs leaving fuel cap just a tad loose as a test but tighten again in a few miles or less as a test I'm thinking on this still,
T
|
|
| |
|
|
Hammer Time
Ultimate Carjunky
/ Moderator
Jun 2, 2019, 1:58 PM
Post #3 of 12
(3110 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
How low are you running the fuel before filling up?
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
We offer help in answering questions, clarifying things or giving advice but we are not a substitute for an on-site inspection by a professional.
|
|
| |
|
|
kuririn
Novice
Jun 2, 2019, 2:01 PM
Post #4 of 12
(3104 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
The low fuel light comes on, so I'd say less than a gallon
|
|
| |
|
|
Hammer Time
Ultimate Carjunky
/ Moderator
Jun 2, 2019, 2:06 PM
Post #5 of 12
(3100 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
Very bad idea and that is likely the reason for your issues.The fuel keeps the pump cooled and lubricated and when you run it low like that, the fuel gets aerated and overheats the pump. Many pumps seize on shut off.
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
We offer help in answering questions, clarifying things or giving advice but we are not a substitute for an on-site inspection by a professional.
|
|
| |
|
|
kuririn
Novice
Jun 2, 2019, 2:10 PM
Post #6 of 12
(3096 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
Then why does it occur ONLY immediately after filling up, and not when the fuel is low? And why does the problem disappear after a few minutes of driving?
|
|
| |
|
|
Hammer Time
Ultimate Carjunky
/ Moderator
Jun 2, 2019, 2:12 PM
Post #7 of 12
(3091 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
Because it is overheated when shut off and that causes it to seize.
One of these times it won't disappear after restarting and you will be towed in.
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
We offer help in answering questions, clarifying things or giving advice but we are not a substitute for an on-site inspection by a professional.
(This post was edited by Hammer Time on Jun 2, 2019, 2:14 PM)
|
|
| |
|
|
kuririn
Novice
Jun 2, 2019, 2:22 PM
Post #8 of 12
(3083 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
OK, so if the fuel pump is the problem then I should be able to replicate this by driving until my fuel low light comes on. Stopping and turning the engine off. Turning the engine on after a couple of minutes WITHOUT gassing up and see if the engine stalls. Correct?
|
|
| |
|
|
kuririn
Novice
Jun 2, 2019, 2:25 PM
Post #9 of 12
(3080 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
BTW forgot to add at the last fillup I only filled it to 3/4 full and had no problem. Only occurs when I fill it to the first click.
|
|
| |
|
|
Hammer Time
Ultimate Carjunky
/ Moderator
Jun 2, 2019, 2:46 PM
Post #10 of 12
(3072 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
I'm not here to try to convince you of anything. Believe what you want. Do whatever you want.
I've replaced many a fuel pump because people ran them out of fuel.
Of course there could be something else causing this problem but I assure you that you will eventually be replacing your fuel pump if you keep this habit up.
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
We offer help in answering questions, clarifying things or giving advice but we are not a substitute for an on-site inspection by a professional.
|
|
| |
|
|
kuririn
Novice
Jun 2, 2019, 2:50 PM
Post #11 of 12
(3069 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
Good to know. Any one else got a handle on what is causing this?
|
|
| |
|
|
Tom Greenleaf
Ultimate Carjunky
/ Moderator
Jun 3, 2019, 2:37 AM
Post #12 of 12
(3038 views)
|
|
Re: 2007 Kia Optima stalls ONLY after fillup
|
|
|
You are causing this by running out of fuel. Now it's not surprise,
T
|
|
| |
|
Auto Repair Home
SEARCH
WHO'S 
LOG 
1989 toyota pickup 3.0 crank no start
Please Help - Knock sound & engine fail
