|
|
|
1998 Dodge Caravan transmission problem
|
|
|
| |
|
|
grayta
User
Jun 20, 2009, 3:32 AM
Post #1 of 9
(16801 views)
|
1998 Dodge Caravan transmission problem
|
|
|
I have a 1998 Dodge Caravan with a 3.0 liter motor and 3 speed automatic transmission. we recently installed a junkyard transmission, and we put a new filter and the correct fluid in it. It worked just fine for a couple weeks and now it does not want to shift into 3rd gear when it is warmed up. It shifts just fine when it is cold, no slipping or anything like that. It has gone into 3rd a couple times when warm, but it downshifts into second gear as soon as you touch the gas pedal. It has no codes come up and the check engine light did not come on. I have a strong feeling that it is something electrical, but I don't know where to start, and I don't want to just start replacing things until I get it right. Any help will be greatly appreciated.
|
|
| |
|
|
Sidom
Veteran
/ Moderator
Jun 20, 2009, 7:11 AM
Post #2 of 9
(16788 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
Those Chrsylers have had a problem with their shift solenoid packs. It's mounted externally on the left side (facing the radiator). If you still have your old tranny, take if off & try it on the new one. Just make sure everything is very clean around it (especially bewteen the pack & tranny case) before you remove it.Get dirt into the valve body & you will be creating more problems that you are trying to solve. You might want to also replace the gasket, it is also common for them to leak from this area as well.
From the dealer they are around $300 so I probably wouldn't go out get one with out making sure that is the problem.....
|
|
| |
|
|
superbob
User
Jul 6, 2009, 12:45 AM
Post #3 of 9
(16758 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
No shift solonoid on the three speed trans, Except t conv clutch. This trans is controlled by mecanical linkage from throttle to lever on trans, try disonnect linkage and see if it shifts? Drive easy! adjustment may be out at the linkage on top of the trans
Bob
|
|
| |
|
|
grayta
User
Jul 20, 2009, 5:24 AM
Post #4 of 9
(16721 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
The problem ended up being the return spring and adjustment on the kick-down linkage. I replaced the spring and then adjusted the linkage in so that it kicks down later and now it works like it is supposed to.
|
|
| |
|
|
superbob
User
Jul 20, 2009, 5:28 AM
Post #5 of 9
(16720 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
sounds like superbob had the right diagnosis!
|
|
| |
|
|
Sidom
Veteran
/ Moderator
Jul 20, 2009, 2:47 PM
Post #6 of 9
(16713 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
Good call Bob.....
I'm sure Tom, Loren or HT will be forecoming with a star that is redeemable at starbucks.......
|
|
| |
|
|
Loren Champlain Sr
Veteran
/ Moderator
Jul 21, 2009, 2:10 PM
Post #7 of 9
(16705 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
 For Bob! Good call.
Loren
SW Washington
|
|
| |
|
|
miami206
New User
Aug 31, 2011, 7:19 PM
Post #8 of 9
(14908 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
I had the same problem,have the same van. My mechanic did a diognostic and he said it was'nt the transmission.theres a module box or an electrical box on the transmission thats connected to dsome plugs.and its square.take that out and replace it. its about 140.00 dollars.I replace it and it ran so smooth,gears changed so smoothly. but they recommended also to change the transmission computer,which is located on the passenger side.also a square box connected with a wiring harness with a screw in the middle.next to the washer and radiator bottles.reason why because after replacing the module on the transmission it did the same thing again, got stuck on one gear after it was hot. So I unplugged the transmission computeron the passenger side and did a restart on the computer and it worked again for a couple of minutes. so i'm pretty sure is both those boxes.change both. NOTE i have not changed the computer yet but im going to, due to lack of time.but i'll get back at u unless u change it first. and it works.
|
|
| |
|
|
Hammer Time
Ultimate Carjunky
/ Moderator
Sep 1, 2011, 3:19 AM
Post #9 of 9
(14900 views)
|
|
Re: 1998 Dodge Caravan transmission problem
|
|
|
This thread is 2 years old. If you have a question, please start a new thread.
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
We offer help in answering questions, clarifying things or giving advice but we are not a substitute for an on-site inspection by a professional.
|
|
| |
|
Auto Repair Home
SEARCH
WHO'S 
LOG 
Lukewarm Heat............
Buy Flualprazolam Powder Online Whatsapp: +1(424) 328-1086
1989 toyota pickup 3.0 crank no start
